Study of Precipitated Secondary Phase at 700 °C on the Electrochemical Properties of Super Duplex Stainless Steel AISI2507: Advanced High-Temperature Safety of a Lithium-Ion Battery Case.

Super duplex stainless steel (SDSS) is a suitable structural material for various engineering applications due to its outstanding strength and corrosion resistance. In particular, its high-temperature strength can enhance the safety of electronic products and cars. SDSS AISI2507, known for its excellent strength and high corrosion resistance, was analyzed for its microstructure and electrochemical behavior at the ignition temperature of Li-ion batteries, 700 °C. At 700 °C, AISI2507 exhibited secondary phase precipitation values of 1% and 8% after 5 and 10 h, respectively. Secondary phase precipitation was initiated by the expansion of austenite, forming sigma, chi, and CrN phases. The electrochemical behavior varied with the fraction of secondary phases. Secondary phase precipitation reduced the potential (From -0.25 V to -0.31 V) and increased the current density (From 8 × 10-6 A/cm2 to 3 × 10-6 A/cm2) owing to galvanic corrosion by sigma and chi. As the fraction of secondary phases increased (From 0.0% to 8.1%), the open circuit potential decreased (From -0.25 V to -0.32 V). Secondary phase precipitation is a crucial factor in reducing the corrosion resistance of SDSS AISI2507 and occurs after 1 h of exposure at 700 °C.

Effect of Secondary Phase on Electroless Ni Plating Behaviour of Super Duplex Stainless Steel SAF2507 for Advanced Li-Ion Battery Case.

The development of Li-ion battery cases requires superior electrical conductivity, strength, and corrosion resistance for both cathode and anode to enhance safety and performance. Among the various battery case materials, super duplex stainless steel (SDSS), which is composed of austenite and ferrite as two-phase stainless steel, exhibits outstanding strength and corrosion resistance. However, stainless steel, which is an iron-based material, tends to have lower electrical conductivity. Nevertheless, nickel-plating SDSS can achieve excellent electrical conductivity, making it suitable for Li-ion battery cases. Therefore, this study analysed the plating behaviour of SDSS plates after nickel plating to leverage their exceptional strength and corrosion resistance. Electroless Ni plating was performed to analyse the plating behaviour, and the plating behaviour was studied with reference to different plating durations. Heat treatment was conducted at 1000 °C for one hour, followed by cooling at 50 °C/s. Post-heat treatment, the analysis of phases was executed using FE-SEM, EDS, and EPMA. Electroless Ni plating was performed at 60-300 s. The plating duration after the heat treatment was up to 300 s, and the behaviour of the materials was observed using FE-SEM. The phase analysis concerning different plating durations was conducted using XRD. Post-heat treatment, the precipitated secondary phases in SAF2507 were identified as Sigma, Chi, and CrN, approximating a 13% distribution. During the electroless Ni plating, the secondary phase exhibited a plating rate equivalent to that of ferrite, entirely plating at around 180 s. Further increments in plating time displayed growth of the plating layer from the austenite direction towards the ferrite, accompanied by a reduced influence from the substrate. Despite the differences in composition, both the secondary phase and austenite demonstrated comparable plating rates, showing that electroless Ni plating on SDSS was primarily influenced by the substrate, a finding which was primarily confirmed through phase analysis.

Subchondral stress fracture of the femoral head (SSFFH) in young and healthy military recruits: clinical recommendations and fracture configurations on MRI.

PURPOSE: This study aimed to evaluate the clinical and radiologic characteristics of the fatigue-type of SSFFH in healthy military recruits. MATERIALS AND METHOD: We retrospectively analyzed 39 hips from 32 patients who were treated for SSFFH between 2014 and 2018. Clinical variables were analyzed. We devised a categorization system that divided SSFFH into five types (A-E) according to the extent of the fracture line MRI axial view. The femoral head was divided into three parts for the categorization: the anterior third, middle third, and posterior third. RESULTS: The included patients were 39 hips from 32 patients with the mean age 22.3 years. Almost all patients with SSFFH (96.9%) complained of hip pain with limping at the time of diagnosis. The mean time to the onset of the hip pain from the beginning of military training was 24.8 days. There were seven patients (21.9%) with concomitant stress fractures on whole-body bone scan. Six hips (15.4%) developed osteoarthritis and required surgery. Almost all the cases (94.9%) involved the anterior compartment of the femoral head. CONCLUSIONS: Military recruits with the hip pain and limping within one month of military training should undergo detailed evaluation. A whole-body bone scan with SPECT is useful for identifying other concomitant stress fractures. Majority of SSFFH involved the anterior compartment of the femoral head.

Cytokine Response to Diet and Exercise Affects Atheromatous Matrix Metalloproteinase-2/9 Activity in Mice.

BACKGROUND: The aim of this study is to identify the principal circulating factors that modulate atheromatous matrix metalloproteinase (MMP) activity in response to diet and exercise.Methods and Results:Apolipoprotein-E knock-out (ApoE-/-) mice (n=56) with pre-existing plaque, fed either a Western diet (WD) or normal diet (ND), underwent either 10 weeks of treadmill exercise or had no treatment. Atheromatous MMP activity was visualized using molecular imaging with a MMP-2/9 activatable near-infrared fluorescent (NIRF) probe. Exercise did not significantly reduce body weight, visceral fat, and plaque size in either WD-fed animals or ND-fed animals. However, atheromatous MMP-activity was different; ND animals that did or did not exercise had similarly low MMP activities, WD animals that did not exercise had high MMP activity, and WD animals that did exercise had reduced levels of MMP activity, close to the levels of ND animals. Factor analysis and path analysis showed that soluble vascular cell adhesion molecule (sVCAM)-1 was directly positively correlated to atheromatous MMP activity. Adiponectin was indirectly negatively related to atheromatous MMP activity by way of sVCAM-1. Resistin was indirectly positively related to atheromatous MMP activity by way of sVCAM-1. Visceral fat amount was indirectly positively associated with atheromatous MMP activity, by way of adiponectin reduction and resistin elevation. MMP-2/9 imaging of additional mice (n=18) supported the diet/exercise-related anti-atherosclerotic roles for sVCAM-1. CONCLUSIONS: Diet and exercise affect atheromatous MMP activity by modulating the systemic inflammatory milieu, with sVCAM-1, resistin, and adiponectin closely interacting with each other and with visceral fat.

Immune reconstitution inflammatory syndrome versus non-immune reconstitution inflammatory syndrome lymphoma in HIV patients on antiretroviral therapy.

Little is known about differences between immune reconstitution inflammatory syndrome (IRIS) and non-IRIS lymphoma in HIV patients on antiretroviral therapy (ART). The aim of this study was to describe the characteristics of IRIS and non-IRIS lymphoma in Korean HIV-positive patients on ART compared with lymphoma in those off ART. Of 1490 patients, 41 (3%) had lymphoma. Of these, 27 cases (66%) were classified as lymphoma off ART, eight as IRIS lymphoma, and six as non-IRIS lymphoma on ART. Hodgkin lymphoma was significantly more common among patients with non-IRIS lymphoma on ART than among those with lymphoma off ART (P = 0.005), whereas there was no Hodgkin lymphoma among IRIS lymphoma. Stage IV lymphoma was significantly rarer in non-IRIS lymphoma on ART than in lymphoma off ART (P = 0.007). Non-IRIS lymphoma on ART tends to have a better survival rate than lymphoma off ART (Kaplan-Meier survival analysis, P = 0.167), while IRIS lymphoma exhibited a survival rate similar to lymphoma off ART (P = 0.618). In Korean HIV-positive patients, there were significantly more cases of Hodgkin lymphoma of a less advanced stage in non-IRIS lymphoma on ART than in lymphoma off ART, in contrast to IRIS lymphoma.

Risk factors for febrile neutropenia during chemotherapy for HIV-related lymphoma.

We evaluated risk factors for neutropenic fever and febrile prolonged neutropenia during vincristine-including chemotherapy to treat HIV-related lymphoma to investigate whether protease inhibitor (PI) treatment is associated with infectious complications due to drug interactions with chemotherapeutic agents. We included all HIV patients who received chemotherapy including vincristine for lymphoma at a single referral center in 1999-2010. Neutropenic fever was defined as absolute neutrophil count < 500 cells/µL with body temperature over 38℃; and prolonged neutropenia was defined if it persisted over 7 days. CODOX-M/IVAC and Stanford regimens were considered high-risk regimens for prolonged neutropenia. We analyzed 48 cycles of chemotherapy in 17 HIV patients with lymphoma. There were 22 neutropenic fever and 12 febrile prolonged neutropenia events. In multivariate analysis, neutropenic fever was associated with old age and low CD4 cell count, but not with PI use or ritonavir-boosted PI use. Low CD4 cell count and high-risk regimens were associated with febrile prolonged neutropenia. Neutropenic fever and febrile prolonged neutropenia is associated with old age, low CD4 cell count, and high-risk regimens, but not PI use, in HIV patients undergoing chemotherapy including vincristine for lymphoma.

Activation of NMDA receptors increases proliferation and differentiation of hippocampal neural progenitor cells.

The prolonged effects of N-methyl-D-aspartate (NMDA) receptor activation on the proliferation and differentiation of hippocampal neural progenitor cells (NPCs) were studied. Under conditions of mitogen-mediated proliferation, a single NMDA pulse (5 microM) increased the fraction of 5-bromo-2-deoxyuridine (BrdU)-positive (BrdU(+)) cells after a delay of 72 hours. Similarly, a single systemic injection of NMDA (100 mg/kg) increased the number of BrdU(+) cells in the dentate gyrus (DG) after 28 days, but not after 3 days. NMDA receptor activation induced an immediate influx of Ca(2+) into the NPCs and the NPCs expressed and released vascular endothelial growth factor (VEGF) in an NMDA receptor-dependent manner within 72 hours. With repetitive stimulation at the same dose, NMDA stimulated the acquisition of a neuronal phenotype accompanied by an increase in the expression of proneural basic helix-loop-helix (bHLH) factors. Together these findings suggest that neurogenesis in the developing brain is likely to be both directly and indirectly regulated by complex interactions between Ca(2+) influx and excitation-releasable cytokines, even at mild levels of excitation. In addition, our results are the first to show that stimulation of NPCs may lead to either proliferation or neuronal differentiation, depending on the level of NMDA receptor activation.

Augmentation of Cav3.2 T-type calcium channel activity by cAMP-dependent protein kinase A.

Ca2+ influx through T-type Ca2+ channels is crucial for important physiological activities such as hormone secretion and neuronal excitability. However, it is not clear whether these channels are regulated by cAMP-dependent protein kinase A (PKA). In the present study, we examined whether PKA modulates Cav3.2 T-type channels reconstituted in Xenopus oocytes. Application of 10 microM forskolin, an adenylyl cyclase stimulant, increased Cav3.2 channel activity by 40+/-4% over 30 min and negatively shifted the steady-state inactivation curve (V50=-61.4+/-0.2 versus -65.5+/-0.1 mV). Forskolin did not affect other biophysical properties of Cav3.2 channels, including activation curve, current kinetics, and recovery from inactivation. Similar stimulation was achieved by applying 200 microM 8-bromo-cAMP, a membrane-permeable cAMP analog. The augmentation of Cav3.2 channel activity by forskolin was strongly inhibited by preincubation with 20 microM N-[2-(4-bromocinnamylamino)ethyl]-5-isoquinoline (H89), and reversed by subsequent application of 500 nM protein kinase A inhibitor peptide. The stimulation of Cav3.2 channel activity by PKA was mimicked by serotonin when 5HT7 receptor was coexpressed with Cav3.2 in Xenopus oocytes. Finally, using chimeric channels constructed by replacing individual cytoplasmic loops of Cav3.2 with those of the Nav1.4 channel, which is insensitive to PKA, we localized a region required for the PKA-mediated augmentation to the II-III loop of the Cav3.2.

A molecular determinant of nickel inhibition in Cav3.2 T-type calcium channels.

Molecular cloning studies have revealed that heterogeneity of T-type Ca2+ currents in native tissues arises from the three isoforms of Ca(v)3 channels: Ca(v)3.1, Ca(v)3.2, and Ca(v)3.3. From pharmacological analysis of the recombinant T-type channels, low concentrations (<50 microM) of nickel were found to selectively block the Ca(v)3.2 over the other isoforms. To date, however, the structural element(s) responsible for the nickel block on the Ca(v)3.2 T-type Ca2+ channel remain unknown. Thus, we constructed chimeric channels between the nickel-sensitive Ca(v)3.2 and the nickel-insensitive Ca(v)3.1 to localize the region interacting with nickel. Systematic assaying of serial chimeras suggests that the region preceding domain I S4 of Ca(v)3.2 contributes to nickel block. Point mutations of potential nickel-interacting sites revealed that H191Q in the S3-S4 loop of domain I significantly attenuated the nickel block of Ca(v)3.2, mimicking the nickel-insensitive blocking potency of Ca(v)3.1. These findings indicate that His-191 in the S3-S4 loop is a critical residue conferring nickel block to Ca(v)3.2 and reveal a novel role for the S3-S4 loop to control ion permeation through T-type Ca2+ channels.

Retrovirally transduced NCAM140 facilitates neuronal fate choice of hippocampal progenitor cells.

Neural cell adhesion molecule (NCAM) influences proliferation and differentiation of neuronal cells. However, only a little is known about the downstream effects of NCAM signalling, such as alterations in gene transcription, which are associated with cell fate choice. To examine whether NCAM plays a role in cell fate choice during hippocampal neurogenesis, we performed a gain-of-function study, using a retroviral vector which contained full-length NCAM140 cDNA and the marker gene EGFP, and found that NCAM140 promoted neurogenesis by activating proneural transcription activators with concurrent inhibition of gliogenesis. The enhanced transcript levels of proneural transcription factors in NCAM140-transduced cells were down-regulated by treatment of the cells with mitogen-activated protein kinase kinase (MEK) inhibitor PD098059. Overall, these findings suggest that NCAM140 may facilitate hippocampal neurogenesis via regulation of proneurogenic transcription factors in an extracellular signal-regulated kinase (ERK)-dependent manner.